|
Joined: May 2002
Posts: 1,585
Campfire Regular
|
OP
Campfire Regular
Joined: May 2002
Posts: 1,585 |
OK, long story short I've got a Savage Smokeless ML that was given to me. It's not that it's inaccurate, it's probably the most frustrating gun I've ever fired in my life. The bore looks great, no rust / pitting / etc. It's not the accutrigger model but it does have a Rifle Basix trigger on it.
I've tried Barnes T-EZ, TMZ, Expanders, Hornady SST (300g). None of them group well but the TMZ bullets sometimes will not even group on a 2x3 FOOT piece of paper. I've tried two different scopes, two different mounts, iron sights, and three different powders.
It's decidedly worse with Smokeless loads than Blackhorn 209. It's about 4" groups with Blackhorn which isn't what I'm looking for but would work in a pinch. With 5744 42g it literally shoots 12" to 14" groups at 100 yards and sometimes I cannot even find the impact on the mentioned 2x3 piece of cardboard. The loads that do not hit most certainly feel like squib loads (less recoil) but why? I am using Winchester 209 primers and the supplied Barnes Sabots.
I'm not real experienced with ML rifles but I have a TC Omega that will consistently group < 2" with 3 different bullets and blackhorn 209.
So I returned this gun to Savage about 6 weeks ago. They looked it over, replaced the breech plug, fired it, and returned it. They sent what is more or less a one hole group target with it. I took it to the range today and it was every bit as bad for me as it's ever been. 3 out of 10 shots didn't impact my target frame at 100 yards and the group was over 10". I'm seating the bullets to the witness mark on my ramrod and I'm out of ideas.
I've ordered some of the short black MMP Sabots that Savage recommended and a box of the 250g .452 XTP they recommended. Is it possible I'm just running into issues with Sabots or is this gun just a turd they didn't fix?
|
|
|
|
Joined: May 2002
Posts: 1,585
Campfire Regular
|
OP
Campfire Regular
Joined: May 2002
Posts: 1,585 |
Oh I yes, I am individually weighing charges and for my own sanity I have three different scales I put the powder charges on just to make sure they were correct.
|
|
|
|
Joined: May 2005
Posts: 6,544
Campfire Tracker
|
Campfire Tracker
Joined: May 2005
Posts: 6,544 |
What has the temperature been when you were shooting. These rifles are known for melting sabots in hot temps. Some guys are using a sub base wad to protect the sabot. A couple of friends of mine had good success with Hornady 300 XTPs and a Harbester Crush Rib sabot over 44 grains of 5744.
|
|
|
|
Joined: May 2007
Posts: 3,251
Campfire Tracker
|
Campfire Tracker
Joined: May 2007
Posts: 3,251 |
winchester w209 primers or winchester 777 primers?
|
|
|
|
Joined: May 2002
Posts: 1,585
Campfire Regular
|
OP
Campfire Regular
Joined: May 2002
Posts: 1,585 |
Standard Winchester 209 primers. It was probably about 80 this morning when I was shooting but the last time it could have been anywhere from 85 to mid 90s, I don't recall. I was wondering if there was any chance of a blown sabot because just shooting a lousy group is one thing even if it's consistent but when you can't even find the impact at all, something certainly went very wrong! I was not shooting slowly but the barrel didn't feel overly hot. When I cleaned it there were probably 10-11 unburnt powder kernels in the bore - not sure if that's to be expected or not?
|
|
|
|
Joined: Dec 2012
Posts: 947
Campfire Regular
|
Campfire Regular
Joined: Dec 2012
Posts: 947 |
In those kind of temps expect a 15min or more wait between shots. Did Savage test it with your scope? I dont think they normally will. Have you shot it with just iron sights?
Have you checked your vent liner. After .035 accuracy goes south.
TMZs are boattails and that usually equals BAD with smokeless. Especially with fast burning powders like 5744.
TEZs come with EZ load sabots, Thats bad too.
SSTs come with red 3 petals EZ load sabots. Again those are bad.
IIRC Savage test loads use SR4759 which is now hard to find. Its a bit slower than burning 5744 but gives better fps.
Try 63-65gr of Reloder7 and 300gr flat based bullets in the MMP black short. Its far more forgiving on sabots and easy to find usually. Harvester black crushribs are usually too loose unless you use a .458 bullet. With a 458 they are usually excellent shooters with the black crushribs
Last edited by Overkill45; 10/09/14.
|
|
|
|
Joined: May 2002
Posts: 1,585
Campfire Regular
|
OP
Campfire Regular
Joined: May 2002
Posts: 1,585 |
Very interesting guys. A friend just picked up 2# of SR 4759 for me, I will get it next week. I order some of these http://mmpsabots.com/store/black-sabot/
|
|
|
|
Joined: Jan 2004
Posts: 3,168
Campfire Tracker
|
Campfire Tracker
Joined: Jan 2004
Posts: 3,168 |
I use the TC bullets with their sabots and 5744 and mine shoot about 2". What load did Savage say they used? I've shot about 100 shots out of mine and never cleaned the barrel, remember with smokeless they do not need to be cleaned like a black powder or triple 7 load.
|
|
|
|
Joined: Sep 2013
Posts: 297
Campfire Member
|
Campfire Member
Joined: Sep 2013
Posts: 297 |
I shoot the 250 grain sst with 46 grains of IMR 4227 with the mmp sabot,tried other combos like the barnes and i dont remember which sabot now but they would barely make it out of the barrel.Accuracy is about 2-3 inches at 100 yards. Hope you get it worked out.
|
|
|
|
Joined: Dec 2012
Posts: 947
Campfire Regular
|
Campfire Regular
Joined: Dec 2012
Posts: 947 |
Excellent Buzz. SR4759 is a good powder. Fairly easy to ignite but not as hard on the sabots as N110 or 5744. I like it better than either of those if you plan on shooting 300gr bullets. N110 gives better FPS but its super hard to find and pressures are really up there with a 300gr. I still like Reloder7 better but SR4759 is more flexible. 250gr bullets are pretty much a no go with Reloder7. BTW you should register on Dougs message board. Its almost all smokeless oriented and they have more knowledge then you will find anywhere on the net.
|
|
|
|
Joined: Dec 2012
Posts: 947
Campfire Regular
|
Campfire Regular
Joined: Dec 2012
Posts: 947 |
I shoot the 250 grain sst with 46 grains of IMR 4227 with the mmp sabot,tried other combos like the barnes and i dont remember which sabot now but they would barely make it out of the barrel.Accuracy is about 2-3 inches at 100 yards. Hope you get it worked out. Savage quit recommending 4227 a while ago. It has ignition issues. If it works for you fine but keep that in mind. Its a known problem.
|
|
|
|
Joined: Sep 2013
Posts: 297
Campfire Member
|
Campfire Member
Joined: Sep 2013
Posts: 297 |
Did not know that,what would be a good substitute? Shoots really good right now.Thanks Shawn.
|
|
|
|
Joined: Nov 2004
Posts: 5,499
Campfire Tracker
|
Campfire Tracker
Joined: Nov 2004
Posts: 5,499 |
I would call Savage and see if they would be so kind as to tell you the load they used, and find out if it was actually shot at 100 yards or 50.
There is no way to coexist no matter how many bumper stickers there are on Subaru bumpers!
|
|
|
|
Joined: Dec 2012
Posts: 947
Campfire Regular
|
Campfire Regular
Joined: Dec 2012
Posts: 947 |
SR4759 or N110 would be my choice for 250gr bullets if you can find them. N110 is and has been super hard to find the last few years.
4759 is being discontinued and supplies are drying up fast.
5744 is filthy compared to most smokeless powders and performance sucks but it the easiest to ignite. If 2050fpsish is ok with you, 5744 is fine and super dependable. Its about as dirty as BH209 though just non corrosive. BH209 actually works really really well in the Savage, just make sure you clean it.
Now if you want to use 300gr bullets there are a couple powders that rock. Reloder7 and H4198 or IMR4198 are good powders and still fairly available. You need quite a bit more powder to be reliable so recoil is going to be higher. N120 is my favorite Savage powder but goooood luck finding it. Its super clean and 300gr bullet performance is excellent with just 58-60grs. You can go as high as 63gr if needed.
At one time Reloder7 was a recommended powder in the first Savage ML and many people still use it in MLIIs. 4198 has a similar burn rate and its a bit cleaner.
Last edited by Overkill45; 10/09/14.
|
|
|
|
Joined: Nov 2004
Posts: 7,107
Campfire Tracker
|
Campfire Tracker
Joined: Nov 2004
Posts: 7,107 |
the 300 grain barnes original with a black harvester crush rib sabot is bread and butter for my gun. I think I was running 70 grains of RL 10 @ 2300 ish fps. groups were a 1 moa easy
|
|
|
|
Joined: Nov 2005
Posts: 1,673
Campfire Regular
|
Campfire Regular
Joined: Nov 2005
Posts: 1,673 |
44 grains of 5744 with a barnes 290 grain tipped mz in a mmp high pressure sabot. Gets me right around 1950fps. Very little recoil shoots flat enough that out to 250 yards I can just hold upper third on a deer. Out of two different savages the combo shoots excellent three shots at a hundred are always around 3/4".
|
|
|
|
Joined: Jul 2008
Posts: 6,575
Campfire Tracker
|
Campfire Tracker
Joined: Jul 2008
Posts: 6,575 |
Waiting between shots, especially at higher temperatures is critical. My groups will go from 1" (cold bore), to 7" (able to feel warmth with my palm.
300g Barnes original with orange sabots, 44.7g of 5744 or 63g Re-7, both accurate.
"...One Nation under God, indivisible, with Liberty and Justice for All"
JeffG
|
|
|
|
Joined: Dec 2007
Posts: 1,258
Campfire Regular
|
Campfire Regular
Joined: Dec 2007
Posts: 1,258 |
Again, waiting is key. Wait at least 15min and/or use a cooling rod. When cool mine can do this: When hot it falls apart. My NULA will do the same thing but prefers Parker bullets and N110 or SR4759. You might give those a try: Or Thor bullets. They don't shoot as well for me but they do away with the sabot:
|
|
|
|
Joined: Dec 2012
Posts: 947
Campfire Regular
|
Campfire Regular
Joined: Dec 2012
Posts: 947 |
7mmfreak
I found that 60gr of N120 was hard to beat but my bore was tighter. I had to use the MMP Orange sabot instead. Sizing the 458s down to .454 also worked great with the Harvester Black CR in mine.
63gr of Reloder7 worked great too but its not nearly as clean as N120. It is far easier to find though. 63gr of Reloder7 gave similar speeds as roughly 58gr of N120. In the 2100-2150fps range IIRC.
The thing i really loved about N120, it does work with 250gr bullets if you want a 2500fps load. You need around 65gr+ to get there. I never tried it in really cold temps to see if it was reliable but a few others claimed it was.
Last edited by Overkill45; 10/10/14.
|
|
|
|
Joined: Sep 2014
Posts: 245
Campfire Member
|
Campfire Member
Joined: Sep 2014
Posts: 245 |
You guys are zeroing in on the smokeless loads.
Why was he shooting 4" groups with BH 209? That gun should shoot BH better than that.
Democracy is two wolves and a lamb voting on what to have for lunch. Liberty is a well-armed lamb contesting the outcome of the vote.
|
|
|
|
560 members (10gaugemag, 1lesfox, 11point, 007FJ, 12344mag, 160user, 51 invisible),
2,536
guests, and
1,243
robots. |
Key:
Admin,
Global Mod,
Mod
|
|
Forums81
Topics1,191,360
Posts18,468,953
Members73,931
|
Most Online11,491 Jul 7th, 2023
|
|
|
|