24hourcampfire.com
24hourcampfire.com
Previous Thread
Next Thread
Print Thread
Hop To
Joined: Apr 2017
Posts: 24
O
New Member
OP Offline
New Member
O
Joined: Apr 2017
Posts: 24
Here's the situation:
gun: Browning A-bolt, .338WM, 26" barrel
load: 225gr. Barnes TTSX, 71.0gr. Reloder 19, WLRM primer, R-P case, COAL 3.370 which is 96 off the lands, chronos at 2830.

I have been shooting this load for over a year, it has been at the range several times and hunting more than once. Never any sign of
pressure issues. Accuracy has been excellent.

I decided to try to develop another load for same rifle:
load: 200gr. Accubond, Reloader 19, WLRM primer, Nosler case, COAL 3.366 (same off the lands as the TTSX).
I loaded a powder ladder from 71.0 to 76.0 in steps of 1.0 up to 74.0 and 0.5 after that.
Nosler powder range for that load (7th edition) is 72.0 - 76.0.
Hornady, Lyman, Speer and Lee all have similar max loads (althrough Lee is a bit more optimistic at 78.0).

The first shot, 71.0gr., gave a normal report and chronoed at 2799, slightly lower than the 225gr. with the same charge.
Upon inspecting the fired case, I observed a very flat primer with some black residue around it. There was no cratering
and no bolt impression in the case head.

I would call that an early high pressure indication. So I put that load away for the day.

Now, powder charge is well below the expected maximum, and the same charge that behaves well with a heavier bullet.
Also, the lighter 200gr bullet seems to be flying slower than the heavier 225gr. in a similar load.

I am using a different case. Nosler brass may be enough thicker to cause somewhat higher pressure, but this much
of a difference?

What am I missing here?

HR IC

Joined: Feb 2014
Posts: 995
S
SEM Offline
Campfire Regular
Offline
Campfire Regular
S
Joined: Feb 2014
Posts: 995
several factors, not enough powder in the case can cause pressure spikes just as much as over charges, incomplete burn or even complete burn early before bullet has cleared the rifle, You already suspect the brass I suspect the charge, The bullets you are comparing are also quite a lot different bearing surface is one, just a thought

sorry I forgot to ask, you fired only one round ?

Last edited by SEM; 09/09/17.

if you want change you have to put in your 2 cents, you can't just sit on the sidelines and whine
Joined: Apr 2017
Posts: 24
O
New Member
OP Offline
New Member
O
Joined: Apr 2017
Posts: 24
Thank you SEM, very interesting. Yes, the bullets certainly have a different bearing surface. I fired the first three shots of the ladder (71.0gr, 72.0gr. and 73.0gr.) All three fired cases looked essentially the same. I stopped there.
I ran the load through QuickLoad, which estimates that 96.5% of the powder (at 71.0gr.) should have burned. I weighed the bullets to make sure they weren't in a mis-labelled box: 199.9 - 200.2gr.

I also backed my TTSX load off 2gr. and loaded 69.0, 70.0 and 71.0gr in the new nosler cases (in stead of the re-loaded R-P cases I have been using). In that load with the TTSX, the fired nosler cases look just like the fired R-P cases (no excessive flattening and no black powder on the head), suggesting the case is not the issue.

However, I do notice that the nosler cases are shorter than I expected. Out of the box new they are 2.484 - 2.489, consistently under the "trim length" for the cartridge. I have been keeping my R-P cases in the 2.491 - 2.499 range. Could that be a factor, I wonder?

Joined: Feb 2014
Posts: 995
S
SEM Offline
Campfire Regular
Offline
Campfire Regular
S
Joined: Feb 2014
Posts: 995
cases being short should not make that much of a difference even if the jump was a little longer, well when you figure it out let us know


if you want change you have to put in your 2 cents, you can't just sit on the sidelines and whine
Joined: Mar 2005
Posts: 26,102
A
Campfire Ranger
Online Content
Campfire Ranger
A
Joined: Mar 2005
Posts: 26,102

My first guess is soft Noz brass. The Noz brass I have for two different cartridges (30-06 and 243) flows into the ejector with minimum loads.........

Casey


Casey

Not being married to any particular political party sure makes it a lot easier to look at the world more objectively...
Having said that, MAGA.
IC B2

Joined: Nov 2011
Posts: 30,607
A
Campfire 'Bwana
Online Content
Campfire 'Bwana
A
Joined: Nov 2011
Posts: 30,607
Sample of one doesn't tell you much.

You need to shoot a few more so you actually have some data to assess.


You didn't use logic or reason to get into this opinion, I cannot use logic or reason to get you out of it.

You cannot over estimate the unimportance of nearly everything. John Maxwell

Moderated by  RickBin 

Link Copied to Clipboard
YB23

Who's Online Now
746 members (10gaugemag, 160user, 10gaugeman, 02bfishn, 12308300, 11point, 87 invisible), 2,789 guests, and 1,255 robots.
Key: Admin, Global Mod, Mod
Forum Statistics
Forums81
Topics1,187,702
Posts18,400,027
Members73,820
Most Online11,491
Jul 7th, 2023


 







Fish & Game Departments | Solunar Tables | Mission Statement | Privacy Policy | Contact Us | DMCA
Hunting | Fishing | Camping | Backpacking | Reloading | Campfire Forums | Gear Shop
Copyright © 2000-2024 24hourcampfire.com, Inc. All Rights Reserved.
Powered by UBB.threads™ PHP Forum Software 7.7.5
(Release build 20201027)
Responsive Width:

PHP: 7.3.33 Page Time: 0.157s Queries: 14 (0.004s) Memory: 0.8124 MB (Peak: 0.8627 MB) Data Comp: Zlib Server Time: 2024-03-29 00:19:46 UTC
Valid HTML 5 and Valid CSS