24hourcampfire.com
24hourcampfire.com
Previous Thread
Next Thread
Print Thread
Hop To
Joined: Dec 2007
Posts: 5,474
L
LouisB Online Happy OP
Campfire Tracker
OP Online Happy
Campfire Tracker
L
Joined: Dec 2007
Posts: 5,474
Read somewhere, most likely on a thread here that some of the Tacoma's are are being shipped with low levels on the 6 speed automatics and to have dealership check it.
Tell the to use the "real check", not some automated system.
Is that something the owner can do?
If I take it to the dealer is there a way to followup to be sure he used to proper procedure to do so IF I can't just do it myself


Some spelling errors can be corrected by a vowel movement.
~ MOLON LABE ~
GB2

Joined: Sep 2011
Posts: 2,637
T
Campfire Regular
Offline
Campfire Regular
T
Joined: Sep 2011
Posts: 2,637
There is a way to do it yourself, but with the sealed system it is a PITA. An immediate giveaway they didn't check manually is if they're done in just a few hours - because it needs to cool off completely before they even begin, like 4 hours just to sit, then do the check which might take an hour or so. Expect it to be there overnight or half the day at least. Because mine was low I wrote Toyota and got a 6 year 100k mile bumper to bumper warranty for free.

Joined: Jan 2012
Posts: 1,111
T
Campfire Regular
Offline
Campfire Regular
T
Joined: Jan 2012
Posts: 1,111
You bring the trans up to normal operating temp. On level ground there is a plug on the bottom of the transmission pan remove plug trans fluid should drip out. The manual says it should be at normal temp............

Joined: Jan 2012
Posts: 1,111
T
Campfire Regular
Offline
Campfire Regular
T
Joined: Jan 2012
Posts: 1,111
A750E AUTOMATIC TRANSMISSION – AUTOMATIC TRANSMISSION FLUID
AUTOMATIC TRANSMISSION FLUID
ADJUSTMENT
1. BEFORE FILLING TRANSMISSION
• This transmission requires Toyota Genuine ATF WS.
• It is necessary to refill the transmission with the
correct amount of fluid.
• The vehicle must remain level while adjusting the
transmission fluid level.
• On vehicles equipped with active suspension, turn the
suspension control switch OFF if it is necessary to jack up the vehicle with the engine running.
2. TRANSMISSION PAN FILL
(a) Remove the refill plug and overflow plug.
AT–135




(b) Fill the transmission through the refill hole until fluid begins to trickle out of the overflow tube.
(c) Reinstall the overflow plug.
3. TRANSMISSION FILL
(a) Fill the transmission with the correct amount of fluid as listed in the table below.
(b) Reinstall the refill plug to avoid fluid splash.
HINT:
If you cannot add the listed amount of fluid, do the following:
Specified Fluid Level Overflow Tube
C113723E01

Repair
Fill Amount
Transmission pan and drain plug removal
1.3 L (1.37 US qts, 1.14 lmp qts)
Transmission valve body removal
3.9 L (4.12 US qts, 3.43 lmp qts)
Torque converter removal
5.3 L (5.60 US qts, 4.66 lmp qts)
Entire transmission assembly
5.3 L (5.60 US qts, 4.66 lmp qts)
AT

CG
DLC3
TC
G029469E01

AT
AT–136
A750E AUTOMATIC TRANSMISSION – AUTOMATIC TRANSMISSION FLUID
• Install the refill plug.
• Allow the engine to idle with the air conditioning
OFF.
• Move the shift lever through entire gear range to
circulate fluid.
• Wait for 30 seconds with the engine idling.
• Stop the engine.
• Remove the refill plug and add fluid.
• Reinstall the refill plug.

Joined: Sep 2004
Posts: 29,383
O
Campfire Ranger
Offline
Campfire Ranger
O
Joined: Sep 2004
Posts: 29,383
I thought the tranny had to be at 130 degrees or something like that as well.

IC B2

Joined: Dec 2007
Posts: 5,474
L
LouisB Online Happy OP
Campfire Tracker
OP Online Happy
Campfire Tracker
L
Joined: Dec 2007
Posts: 5,474
Interesting, so fluid will just drip out of the bottom of the pan if all is well?

Can ya tell I am used to manuals?


Some spelling errors can be corrected by a vowel movement.
~ MOLON LABE ~
Joined: Nov 2015
Posts: 315
W
WRO Offline
Campfire Member
Offline
Campfire Member
W
Joined: Nov 2015
Posts: 315
Originally Posted by LouisB
Read somewhere, most likely on a thread here that some of the Tacoma's are are being shipped with low levels on the 6 speed automatics and to have dealership check it.
Tell the to use the "real check", not some automated system.
Is that something the owner can do?
If I take it to the dealer is there a way to followup to be sure he used to proper procedure to do so IF I can't just do it myself



They have to keep your rig over night to check it. The fluid needs to settle in the transmission. Toyota will give you a rental car while you wait.

Mine had it.

Joined: Jun 2005
Posts: 13,230
T
Campfire Outfitter
Offline
Campfire Outfitter
T
Joined: Jun 2005
Posts: 13,230

Louis,

Do you recall if the concern was over Mexican-assembled, Texas-assembled, or both?

Joined: Dec 2007
Posts: 5,474
L
LouisB Online Happy OP
Campfire Tracker
OP Online Happy
Campfire Tracker
L
Joined: Dec 2007
Posts: 5,474
tjm
I think the original posting was here on 24 Hour and I don't think it mentioned assembly location.
One answer was so detailed I am sure whoever they are, that they can shed some light on the issue.
I am still dumbfounded at pulling a plug on the pan and only expecting a drip (maybe the dip on a plugged system is like changing elements on a water heater)


Some spelling errors can be corrected by a vowel movement.
~ MOLON LABE ~
Joined: Dec 2007
Posts: 5,474
L
LouisB Online Happy OP
Campfire Tracker
OP Online Happy
Campfire Tracker
L
Joined: Dec 2007
Posts: 5,474
tjm
I think the original posting was here on 24 Hour and I don't think it mentioned assembly location.
One answer was so detailed I am sure whoever they are, that they can shed some light on the issue.
I am still dumbfounded at pulling a plug on the pan and only expecting a drip (maybe the dip on a plugged system is like changing elements on a water heater).

I wonder if they will really check it or just tell me "it's all good", that is why I wondered if it was a owner project or dealer only.
Also trying to avoid two trips into town t take it in and go get it.

Guess I will crawl under there and see if there is any thread locker or tamper marking paint before I decide whether it do it myself.

Last edited by LouisB; 05/30/18.

Some spelling errors can be corrected by a vowel movement.
~ MOLON LABE ~
IC B3

Joined: May 2010
Posts: 7,290
P
Campfire Tracker
Online Content
Campfire Tracker
P
Joined: May 2010
Posts: 7,290
Friends daughter had a BMW with a sealed engine oil system. Engine was very, very low on oil and it blew up. Wouldn’t own a vehicle without an oil dipstick....


"When the going gets weird, the weird turn pro."
Hunter S. Thompson
Joined: Apr 2004
Posts: 42,583
S
Campfire 'Bwana
Offline
Campfire 'Bwana
S
Joined: Apr 2004
Posts: 42,583
Changed the trans fluid on a pair of 2012 Tacomas when I was on the east coast last year...

pulled the drain plug and let them drain out...poured the fluid in a milk jug to see how much I drained out
of each.. exactly a gallon...

to fill it, I pulled the top line to the trans oil cooler... with a small funnel, slowly poured in the correct amount
of replacement fluid...meeting Toyota T 1, T2 T4 and WS specs...

dealer wanted $400 per vehicle...me doing it saved my wife's g/f and son..$800 and cost $42 in 2 gallons of fluid.


"Minus the killings, Washington has one of the lowest crime rates in the Country" Marion Barry, Mayor of Wash DC

“Owning guns is not a right. If it were a right, it would be in the Constitution.” ~Alexandria Ocasio Cortez

Joined: Dec 2007
Posts: 5,474
L
LouisB Online Happy OP
Campfire Tracker
OP Online Happy
Campfire Tracker
L
Joined: Dec 2007
Posts: 5,474
Seafire

Did you do filter also?


Some spelling errors can be corrected by a vowel movement.
~ MOLON LABE ~

Moderated by  RickBin 

Link Copied to Clipboard
YB23

Who's Online Now
677 members (1lessdog, 17CalFan, 10gaugemag, 1beaver_shooter, 1minute, 10ring1, 74 invisible), 2,737 guests, and 1,281 robots.
Key: Admin, Global Mod, Mod
Forum Statistics
Forums81
Topics1,187,647
Posts18,399,078
Members73,817
Most Online11,491
Jul 7th, 2023


 







Fish & Game Departments | Solunar Tables | Mission Statement | Privacy Policy | Contact Us | DMCA
Hunting | Fishing | Camping | Backpacking | Reloading | Campfire Forums | Gear Shop
Copyright © 2000-2024 24hourcampfire.com, Inc. All Rights Reserved.
Powered by UBB.threads™ PHP Forum Software 7.7.5
(Release build 20201027)
Responsive Width:

PHP: 7.3.33 Page Time: 0.106s Queries: 14 (0.003s) Memory: 0.8494 MB (Peak: 0.9502 MB) Data Comp: Zlib Server Time: 2024-03-28 17:53:53 UTC
Valid HTML 5 and Valid CSS